|本期目录/Table of Contents|

[1]池汝安,詹斯维,张越非,等.葛根总黄酮在乙醇无机盐双水相体系中的萃取[J].武汉工程大学学报,2014,(03):1-7.[doi:103969/jissn16742869201403001]
　CHI Ru an,ZHAN Si wei,ZHANG Yue fei,et al.Extraction of flavonids from Pueraria lobata usingethanol/inorganic salts aqueous twophase system[J].Journal of Wuhan Institute of Technology,2014,(03):1-7.[doi:103969/jissn16742869201403001]
点击复制

葛根总黄酮在乙醇无机盐双水相体系中的萃取(/HTML)
分享到：

《武汉工程大学学报》[ISSN:1674-2869/CN:42-1779/TQ]

卷:
期数:
2014年03期
页码:
1-7
栏目:
化学与化学工程
出版日期:
2014-03-31

文章信息/Info

Title:
Extraction of flavonids from Pueraria lobata usingethanol/inorganic salts aqueous twophase system
文章编号:
16742869(2014)03000107
作者:
池汝安1; 2; 詹斯维1; 2; 张越非1; 2; 陈哲1; 2; 刘哲1; 2; 李娅丽1; 2
1.武汉工程大学化工与制药学院，湖北 武汉 430074 ；2.绿色化工过程教育部重点实验室（武汉工程大学），湖北 武汉 430074
Author(s):
CHI Ruan1; 2; ZHAN Siwei1; 2; ZHANG Yuefei1; 2; CHEN Zhe1; 2; LIU Zhe; LI Yali1; 2
1.School of Chemical Engineering and Pharmacy, Wuhan Institute of Technology,Wuhan 430074,China;2.Key Laboratory for Green Chemical Process of Ministry of Education(Wuhan Institute of Technology),Wuhan 430074,China
关键词:
系; 乙醇/磷酸氢二钾体系; 葛根总黄酮; 萃取
Keywords:
aqueous twophase system; ethanol/dipotassium hydrogen phosphate system; total flavonids of Pueraria lobata; extraction
分类号:
TQ028.4;R284.2
DOI:
103969/jissn16742869201403001
文献标志码:
A
摘要:
双水相体 根据乙醇/无机盐双水相体系的分相能力差异与葛根总黄酮在其中的分配差异，用双水相对葛根总黄酮进行萃取纯化.先在室温25 ℃下用浊点法分别绘制研究乙醇与氯化钠、碳酸钠、磷酸氢二钾、碳酸钾、硫酸铵5种盐所组成的双水相体系的相图，并计算萃取后葛根总黄酮在各体系中的分配系数和萃取率，筛选出乙醇/磷酸氢二钾体系为最佳体系.然后考察改变该体系中水与乙醇体积比和盐的量对体系相比以及葛根总黄酮的分配系数和萃取率的影响，确定最佳组成.最后考察了葛根粗提取液中葛根总黄酮浓度变化对其分配系数和萃取率的影响.结果表明乙醇质量分数为50.14%、磷酸氢二钾质量分数为22.67%的双水相体系是分离纯化葛根总黄酮的最佳条件;在一定质量浓度范围内，葛根总黄酮质量浓度越高，葛根总黄酮在双水相体系中的分配系数越大，当葛根粗提物质量浓度超过0.014 g/mL后，分配系数减小；质量浓度的改变对萃取率影响不大；在最佳萃取条件下，葛根总黄酮在体系中的分配系数为35.99，萃取率高达99.23%.该双水相萃取技术操作简单、环保无害，并对葛根粗提取液中葛根总黄酮的分离纯化有较好的效果.
Abstract:
According to the diversity of phase separation ability and the distribution of target products in the ethanol/inorganic salts aqueous twophase system (ATPS),ATPS was used to extract and purify total flavonids of Pueraria lobata.The phase diagrams of ethanol/sodium chloride,ethanol/sodium carbonate,ethanol/dipotassium hydrogen phosphate,ethanol/potassium carbonate and ethanol/ammonium sulfate ATPS were drawn and investigated at room temperature of 25 ℃ by the cloud point method,respectively.The ethanol/dipotassium hydrogen phosphate system was selected as the optimum system for the extraction of total flavonids after the distribution coefficient and the extraction yield was calculated.Then the distribution coefficients and the extraction yield of puerariae flavonids were studied under the different proportion of ethanol to dipotassium hydrogen phosphate of ATPS,and the optimal composition was determined.Finally the effect of the concentration of total flavonids on the distribution coefficient and the extraction yield was investigated.The results show that the optimal extraction condition of total flavonids is got as the ATPS with ethanol 50.14% (w/w) and dipotassium hydrogen phosphate 22.67% (w/w) ;meanwhile the distribution coefficient increases with the total flavonids concentration increase;however the distribution coefficient begins to decrease when the concentration of crude extract of Pueraria lobata is over 0.014 g/mL;finally,the distribution coefficient is 35.99 and the extraction yield of puerariae flavonids reaches 99.23%,respectively.The aqueous twophase extraction (ATPE) has a good effect on the separation and purification of total flavonids of Pueraria lobata.

参考文献/References:

［1］国家药典委员会．中国药典［S］．Ⅰ部.北京：化学工业出版社，2005：233. The State Pharmacopoeia Commission.Chinese pharmacopoeia［S］.I Department.Beijing:Chemical Industry Press,2005:233. (in Chinese)［2］北京中医药大学．中药化学［M］．贵州：贵州人民出版社，1990：500506. Beijing University of Chinese Medicine.Chinese medicine chemical［M］.Guizhou:Guizhou People Press,1990:500506.(in Chinese)［3］郭延生．葛根有效成分葛根素的提取、分离及结构改造［D］．甘肃：甘肃农业大学，2004. GUO Yansheng.Extraction,isolation,structural modification of puerarin from Pueraria lobata［D］.Gansu:Gansu University of Agricultural,2004.(in Chinese)［4］陈丛瑾，屈丽娟，陈东．双水相萃取法分离纯化黄酮类化合物的研究进展［J］．应用化工，2010，39(10)：15871589. CHEN Congjin,QU Lijuan,CHEN Dong.Research progress on separation and purification of flavonoids by aqueous twophase systems extraction［J］.Applied Chemical Industry,2010,39(10):15871589.(in Chinese)［5］霍清．葛根素双水相体系中的分配特性及分配系数的关联［J］．沈阳药科大学学报，2006，23(3)：139144. HUO Qing.Measurement and correlation of partition coefficient of puerarin in aqueous twophase system［J］.Journal of Shenyang Pharmaceutical University,2006,23(3):139144.(in Chinese)［6］霍清．葛根素在双水相体系中分配特性的研究［J］．北京中医药大学报，2004，27(4)：5153.HUO Qing.Investigation into the characteristics of partition coefficients of puerarin in the aqueous twophase systems［J］.Journal of Beijing University of TCM,2004,27(4):5153.(in Chinese)［7］王志辉，朱建航，郑楠，等．葛根素在乙醇/硫酸铵两水相体系中的分配特性［J］．时珍国医国药，2008，19(1)：1315. WANG Zhihui,ZHU Jianhang,ZHENG Nan,et al.The partition properties of puerarin in aqueous twophase system of ethanol/ammonium Sulfate［J］.Lishizhen Medicine and Materia Medica Research,2008,19(1):1315.(in Chinese)［8］XU Huaneng，HE Chaohong．Extraction of isoflavones from stem of Pueraria lobata (Wild.) Ohwi using nbutanol/water twophase solvent system and separation of daidzein［J］．Separation and Purification Technology，2007，56(1)：8589.［9］钟玲，张越非，李小菊，等．乙醇/无机盐双水相体系分离纯化黄芪总黄酮的研究［J］．中国中药杂志，2012，37 (22)：33953399. ZHONG Ling,ZHANG Yuefei,LI Xiaoju,et al.Separation and purification of total flavonids of astragalus membranaceus with ethanol/phosphate aqueous twophase system［J］.China Journal of Chinese Materia Medica,2012,37(22):33953399.(in Chinese)［10］刘国兴，江波，王元好，等．乙醇/碳酸钾双水相萃取盾叶薯蓣发酵液中的2,3丁二醇［J］．化工学报，2009，60(11)：27982804. LIU Guoxing,JIANG Bo,WANG Yuanhao,et al.Aqueous twophase extraction 2,3butanediol by ethanol/potassium carbonate system from dioscorea zingiberensis fermentative borths［J］.Journal of Chemical Industry and Engineering(China),2009,60(11):27982804.(in Chinese)

相似文献/References:

[1]池汝安,詹斯维,张越非,等.以乙醇/无机盐双水相体系对葛根总黄酮的萃取纯化[J].武汉工程大学学报,2014,(03):66.
　CHI Ru-an,ZHAN Si-wei,ZHANG Yue-fei,et al.Extraction of flavonids from pueraria lobata using ethanol-inorganic salts aqueous two-phase system[J].Journal of Wuhan Institute of Technology,2014,(03):66.

备注/Memo

备注/Memo:
收稿日期：20131017基金项目：国家自然科学基金项目（21006075）；武汉市青年科技晨光计划项目（201271031400）作者简介：池汝安（1959），男，福建三明人，教授，博士，博士研究生导师．研究方向：分离与富集.
更新日期/Last Update: 2014-04-18